pillar extraction coal mining
Home > Products > pillar extraction coal mining

pillar extraction coal mining

Pillar Extraction - an overview | ScienceDirect Topics

Longwall mining or coal pillar extraction by any other method causes the roof to subside and the floor to heave. The “gas emission space” created by such coal extraction can extend 1000 ft above and 250 ft below the working seam depending on the width of the panel. Any coal seam contained in the gas emission space will release gas contained ...

Read More

Coal pillar extraction experiences in New South Wales

2009-8-27 · pillar extraction in New South Wales is dwindling, these early successes with this mining method have ensured that pillar extraction is still successfully conducted today. Current full pillar extraction in New South Wales As mentioned, four full pillar extraction operations in New South Wales were visited. One operation was in the

Read More

Risk management of underground coal pillar

Indian coal mining industry encounters considerable stack of coal seams, standing on pillars. ... Practices of residual coal pillar extraction have been conducted in many countries including UK [5

Read More

Pillar Extraction using Continuous Miners -

PILLAR EXTRACTION USING CONTINUOUS MINERS. Overview. Now that longwall equipment has been developed to a stage where it is able to cope with most conditions satisfactorily, longwall mining is the most widely used method of secondary extraction. However, there are still mines and occasions where longwall mining is not suitable e.g.

Read More

Key success elements of coal pillar extraction in New ...

2009-8-27 · the four full pillar extraction and three partial pillar extraction sites visited in New South Wales. These will be discussed under the broad headings of Section 138, geotechnical mapping, caving of the immediate roof, mining method, temporary support, mining equipment and training. Section 138 of the New South Wales Coal Mines Regulations Act ...

Read More

Coal Mining –The 2 Most Basic Techniques Of

2021-3-1 · There are three methods that can be used in underground mining – room-and-pillar, long wall, or short wall. Once the coal has been removed from the mine, from either of the techniques, it is taken to a preparation plant. This plant is located near the site of mining. Here the coal is cleaned and processed. All the unwanted material like dirt ...

Read More

Pillar Extraction | SpringerLink

2016-2-3 · Abstract. Pillar extraction, (also referred to as retreat mining; pillar recovery; stooping; pillar robbing; and bord and pillar second workings) is the practice of forming a series of pillars and then partially or totally extracting some or all of the pillars, usually with mining operations retreating out of a panel. There are a number of basic pillar extraction methods, with numerous ...

Read More

Coal mining - Underground mining | Britannica

Often the extraction of coal from the seam during mine development is called “first mining”; the extraction of the remaining seam is called “second mining.” Mining methods. Modern underground coal-mining methods can be classified into four distinct categories: room-and-pillar, longwall, shortwall, and thick-seam. Room-and-pillar mining

Read More

Abel Mine Pillar Extraction Training - Cornett's Corner

2020-12-18 · Pillar Extraction Definitions Fender –is a pillar with a short life cycle. As per MDG 1005 design w/h > 2.5 to 3 Lift –a slice of coal 3.6m wide (CM03) taken out of the fender (approx 140-160 tonnes of coal) Stooks –Provides temporary roof support

Read More

WO2015056201A1 - Pillar extraction mining method -

Disclosed is a method of mining or extracting a support pillar from an underground room and pillar mining operation which includes forming (by eg forming top and bottom wedge shaped cuts) at least one removable segment in a pillar (7) and moving (eg pulling) the segment substantially intact from its original location (10A) to a mining position (10C) distal from its original location ...

Read More

Coal pillar extraction at deep cover: With special ...

2011-5-1 · Research Highlights Indian geo-mining scenario of coal pillar extraction is provided. Status of bord and pillar mining for deep coal seams is reviewed. Inherited instability issues of natural support during depillaring of a deep seam under competent roof (high stress conditions) are discussed. Influence of caving of competent overlying strata during extraction of deep seated pillars is shown ...

Read More

Key success elements of coal pillar extraction in New ...

2009-8-27 · the four full pillar extraction and three partial pillar extraction sites visited in New South Wales. These will be discussed under the broad headings of Section 138, geotechnical mapping, caving of the immediate roof, mining method, temporary support, mining equipment and training. Section 138 of the New South Wales Coal Mines Regulations Act ...

Read More

Method of underground mining by pillar extraction -

A method of sublevel caving and pillar and top coal extraction for mining thick coal seams includes the advance mining of rooms and crosscuts along the bottom of a seam to a height of about eight feet, and the retreat mining of the top coal from the rooms, crosscuts and portions of the pillars remaining from formation of the rooms and cross-cuts.

Read More

UNDERGROUND COAL MINING: FACTORS, COST, AND

2013-2-12 · • Pillar sizes will generally range from 30 to 100 feet and have a rectangular configuration • Extraction Ratio is the ratio of coal removed compared to estimated in-place tonnage – normal extraction ratio is from 35 to 55% – retreat mining will result in extraction ratios of up to 70%

Read More

Abel Mine Pillar Extraction Training - Cornett's Corner

2020-12-18 · Pillar Extraction Definitions Fender –is a pillar with a short life cycle. As per MDG 1005 design w/h > 2.5 to 3 Lift –a slice of coal 3.6m wide (CM03) taken out of the fender (approx 140-160 tonnes of coal) Stooks –Provides temporary roof support

Read More

depllaring in coal mines - SlideShare

2016-9-18 · depllaring in coal mines 1. Name- Akhilesh Kumar Gupta Roll NO-114mn0275 Year-2015-2016 2. INTRODUCTION Bord and Pillar method of mining is one of the oldest methods.Pillars are left as support and output is nearly 20%.after development pillars are being extracted which follows different procedure according to the geographical condition. And extraction of pillars inc

Read More

Sizing of Final Stumps for Safer Pillar Extraction

2012-8-29 · Pillar extraction mining methods; (a) Christmas tree, (B) outside lift and (C) three cut. Analysis of the plans suggests that remnant pillar sizing varies considerably among room and pillar retreat mines. Thirteen plans ... “Room and Pillar Retreat Mining, A Manual for the Coal

Read More

(PDF) APPLICATION OF DIFFERENT PILLAR

In India, Coal mining is carried out by both opencast and underground methods, where opencast mining contributed about 93.69% of the total production, whereas the underground mining contributed ...

Read More

CDC - Mining - Deep Cover Pillar Extraction in the U.S ...

ARMPS - Analysis of Retreat Mining Pillar Stability - 6.2.02; Coal Mine Bumps: Five Case Studies in the Eastern United States; Deep Cover Pillar Recovery in the US; Optimum Mine Designs to Minimize Coal Bumps: A Review of Past and Present U.S. Practices; Pillar Design and Strategies for Retreat Mining

Read More

WO2015056201A1 - Pillar extraction mining method -

Disclosed is a method of mining or extracting a support pillar from an underground room and pillar mining operation which includes forming (by eg forming top and bottom wedge shaped cuts) at least one removable segment in a pillar (7) and moving (eg pulling) the segment substantially intact from its original location (10A) to a mining position (10C) distal from its original location ...

Read More

Method of underground mining by pillar extraction -

A method of sublevel caving and pillar and top coal extraction for mining thick coal seams includes the advance mining of rooms and crosscuts along the bottom of a seam to a height of about eight feet, and the retreat mining of the top coal from the rooms, crosscuts and portions of the pillars remaining from formation of the rooms and cross-cuts.

Read More

Commonly used mining techniques to extract coal |

The underground mining includes six type of mining methods that include longwall mining, continuous mining, room and pillar mining, blast mining, shortwall mining and retreat mining. In room and pillar mining, coal deposits are mined by creating a network of rooms into the coal seam. Pillars of coal are left at the site to support the roof.

Read More

UNDERGROUND COAL MINING: FACTORS, COST, AND

2013-2-12 · • Pillar sizes will generally range from 30 to 100 feet and have a rectangular configuration • Extraction Ratio is the ratio of coal removed compared to estimated in-place tonnage – normal extraction ratio is from 35 to 55% – retreat mining will result in extraction ratios of up to 70%

Read More

Coal mining - Underground mining | Britannica

Coal mining - Coal mining - Underground mining: In underground coal mining, the working environment is completely enclosed by the geologic medium, which consists of the coal seam and the overlying and underlying strata. Access to the coal seam is gained by suitable openings from the surface, and a network of roadways driven in the seam then facilitates the installation of service facilities ...

Read More

depllaring in coal mines - SlideShare

2016-9-18 · depllaring in coal mines 1. Name- Akhilesh Kumar Gupta Roll NO-114mn0275 Year-2015-2016 2. INTRODUCTION Bord and Pillar method of mining is one of the oldest methods.Pillars are left as support and output is nearly 20%.after development pillars are being extracted which follows different procedure according to the geographical condition. And extraction of pillars inc

Read More

Coal mining | World Coal Association

Longwall mining involves the full extraction of coal from a section of the seam, or ‘face’ using mechanical shearers. The coal ‘face’ can vary in length from 100-350m. Self-advancing, hydraulically-powered supports temporarily hold up the roof while coal is extracted.

Read More

Hard-rock room and pillar - QueensMineDesignWiki

2019-6-28 · Room and pillar is an underground mining method that has applications to a wide variety of hard-rock deposits worldwide. It is commonly classified as an open-stoping method, meaning that development involves mining out underground cavities while leaving the surrounding un-mined waste or ore as primary support.

Read More

CDC - Mining - Deep Cover Pillar Extraction in the U.S ...

ARMPS - Analysis of Retreat Mining Pillar Stability - 6.2.02; Coal Mine Bumps: Five Case Studies in the Eastern United States; Deep Cover Pillar Recovery in the US; Optimum Mine Designs to Minimize Coal Bumps: A Review of Past and Present U.S. Practices; Pillar Design and Strategies for Retreat Mining

Read More

Research on Non-Pillar Coal Mining for Thick and

This article introduces a new non-pillar coal mining technology (i.e., Gob-side Entry Retaining by Roof Cutting (GERRC)) under the condition of thick and hard roofs. First, we theoretically analyzed the solution to the large suspension span of the thick and hard roof in coal mining. Three-Zone pre-split blasting design in non-pillar coal mining for thick and hard roofs was proposed, based on ...

Read More

WO2015056201A1 - Pillar extraction mining method -

Disclosed is a method of mining or extracting a support pillar from an underground room and pillar mining operation which includes forming (by eg forming top and bottom wedge shaped cuts) at least one removable segment in a pillar (7) and moving (eg pulling) the segment substantially intact from its original location (10A) to a mining position (10C) distal from its original location ...

Read More